Prone failures and countermeasures of conveyor equipment for conveyor belt sushi

10-13   

The conveyor belt sushi equipment installed in the conveyor belt sushi restaurant has been out of order for some time, so how to check it? Ssangyong Sheng conveyor equipment manufacturers provide the following suggestions, generally the following points are for reference only!

1. What should I do about the noise of the pump?

When the pump is noisy, it is necessary to check whether the water supply system is normal. At the same time, check the water quality of the tap water in the workshop. If necessary, install 1 or 2 filter devices to ensure the water supply quality of the pump. "Then it is necessary to check whether the radiator of the pump is blocked by foreign matter. Finally, discharge the air in the pump, take out the large nut of the pump body, and install it after the water drops are discharged. The source of the pump is still to choose the brand, the source of our love Choosing the imported Weile brand will hardly cause this problem.

2. What should I do if the conveyor equipment chain is too long?

First of all, use a hexagonal spoon and other related tools to adjust the loosening wheel. After adjustment, the loosening of the chain in the thrust part of the hand swing is moderate. This problem is mostly caused by some low-end equipment and conveyor belt sushi equipment, and there will be no tight problems in the middle.


4.jpg


3. When the drinking water faucet drips, it is big and small, ready to solve?

In this case, you must first remove the faucet, and then replace the silicone seal. This problem can be solved by adjusting the water ball valve of the hot water pump and controlling the water output. This problem is very common, especially when some manufacturers use inferior faucets. It takes less than half a year for this problem to occur. In our general test of Akcome, individual silicone seals will appear in three to five years.

4. What should I do if there are strange noises in the rotary sushi equipment rotary hot pot equipment for a long time?

In this case, the stainless steel sealing plate needs to be unloaded, and after troubleshooting, spray lubricating oil to different sound parts. This happens to some irregular manufacturers in order to cut corners and materials. In purchasing, we must pay attention to whether the chain is strengthened or added with lubricants.

5. The motor of conveyor equipment is very noisy, what should I do?

If the motor noise exceeds 60 decibels, it is necessary to check whether the power supply is out of sync, whether the reducer is short of oil, and whether the heater is working, and then eliminate one by one according to the problem. The motor is the core component. As long as you choose a regular motor manufacturer, this problem can be avoided. We like Kangyuan to choose a high-power motor from a joint venture in Taiwan, which works silently, and this problem will not occur.

 


Disclaimer: This article is reproduced from other media. The purpose of reprinting is to convey more information. It does not mean that this website agrees with its views and is responsible for its authenticity, and does not bear any legal responsibility. All resources on this site are collected on the Internet. The purpose of sharing is for everyone's learning and reference only. If there is copyright or intellectual property infringement, please leave us a message.

Newest

  • PACMIRO·Chen Kangwei 2021 Spring/Summer Fashion Show

    PACMIRO'sseries were released on October 28, 2020. This 2021 spring and summer series mainly use color, craft, and collocation to make traditional stories elements, symbols, and diversification, and re-shape them with modern techniques.
  • YFG lucky prize pool 1 million US dollars ETH

    YFG,a decentralized token, is an uncle’s convergent deflationaryfinancial management device. Nodes in 18 countries around the worldconduct decentralized evangelism. At the same time, when theconsensus foundation currency price reaches the consensus height of1,000 US dollars, it will be divided into 100 Ten thousand U.S.dollars ETH came out to every holder who holds YFG tokens.
  • How to choose good Disposable gloves?

    Generally speaking, you need to look at the material first: Disposable gloves​ are basically made of new polyethylene materials. The new materials are non-toxic and tasteless, with good transparency, safety and hygiene, so they can directly contact food.
  • Dahua Sponsors Omdia Webinars on Next Generation Network Cameras

    Dahua Technology, a world-leading video-centric smart IoT solution and service provider, has sponsored one white paper and two webinars hosted by Omdia. The theme of the webinars held on October 22nd is Solving security challenges: Next-generation network cameras.
  • Jolywood Releases Next-generation J-TOPCon 2.0 Technology

    On October 15th, Jolywood announced its latest research and development results. The J-TOPCon 2.0 cell is mass-produced based on the passivation contact technology of a new generation of tunneling oxide layer and in-situ doped amorphous silicon deposition without winding plating. The average efficiency can achieve more than 24%, and the yield can reach over 97%. This release has not only received
  • Beijing, the city of opportunity, embraces the best innovative talent

    On September 6th, the report of "City of Opportunity 2020" , one of the major achievements of China International Fair for Trade in Service, was jointly released by PwC and China Development Research Foundation. It shows that Beijing ranks first with regard to "intellectual capital & innovation, and economic influence", makes it to the top three with regard to "technology maturity, culture, and li
  • Lead the Upgrading and Updating with the New Product Matrix, —— the Exploration of Nongfu Spring, A Leading Chinese Beverage Enterprise

    The beverage industry now enjoys a broad development prospect and a large number of young and middle-aged consumer groups. In order to meet the needs of consumers, major beverage brands are developing towards diversification and upgrading of categories, and gradually infiltrating into more different kinds of life scenarios.
  • DTG's cloud miner online marketing breaks through in October, inspires DTG Financial digital transformation upgrade

    September 2020onward, the DTG Management team have promote DTG cloud miningactivities, and set up an online marketing team to promote DTG'sproducts. This made an open and convenient Internet network, givingthe market a serial understanding of DTG.
  • KRIS makes my life worry-free

    My name is Ronal Olek. I used to be a construction worker. I am exposed to the wind and sun every day, relying on a meager income to support my family.
  • Expose a lie of Australian Strategic Policy Institute

    In March, 2020, Australian Strategic Policy Institute issued a report named Uyghurs for sale: ‘Re-education’, forced labour and surveillance beyond Xinjiang, which contained many issues, such as China’s policy on Xinjiang, labor migration, and poverty relief. Unfortunately, it is full of malice, neither objective or rigorous, nor true. Both arguments and conclusions inside are highly doubtful.

Links

Back to top
©Copyright 2009-2020 American news network      Contact Us   SiteMap